mast raising on Chat 18 catamaran

Mast raising without a crane sounds a daunting prospect but it is actually very straightforward if you prepare properly. Some years ago I wrote an article which you can see here, https://www.sailingcatamarans.com/index.php/articles/11-technical-articles/268-safe-mast-lowering-method so this is really just an update. This video shows my Chat 18, which has a mast from a beach cat, and thus one that could be pushed up by hand, but here I show the system that works on any size mast - the biggest I have raised this way was on a 50ft ketch. The key features are a good tabernacle, a "gin pole" - in this case the boom - and most important, the use of temporary shrouds thus ensuring that the mast cannot fall sideways. These shrouds must have "chainplates" that line up exactly with the tabernacle pivot bolt. When down the mast rests on a, eg, dinghy trailer mast support at the back of the cockpit. If you regularly raise you mast you can fit a trailer roller to the bracket, so it's easy to push the mast to and fro for trailering. The "gooseneck" for the ginpole is a shroud adjuster from my junk box, suitably bent and screwed to the front of the mast. Roller reefing gear has to be kept straight and has a tendency to catch on the cabin roof etc. So I always lash it to the ginpole in about the right position. The "chainplates" for the temporary shrouds are, again, from my junk box and are 25mm OD aluminium tubes that clip into place and are easily removed. They also take guywires from the forward end of the ginpole to stop that falling over. I attached the spi halyard to the ginpole, but you can just rely on the forestay/furling gear. The mast is then raised up using the mainsheet shackled to the forestay chainplate (you may need a longer rope, depending on your boat). 4:1 is easy on small boats, on bigger boats lead it back to a winch. Of course the most load is when the mast is horizontal, you often have to push on the mast when lowering to get it to start moving. So if you can get it off the support you know you can hoist it all the way. So it all seems a lot of ropes and preparation but it's all worth it as the mast cannot fall and you always have total control, even in a cross wind. And you can usually raise the mast singlehanded. If you are only occasionally raising/lowering the mast then the temporary stays can be rope. Make a loop in the end and pass it over the spreaders and round the mast using a boathook or, on bigger boats, a bosun's chair. Easy to pull off again afterwards. Before sailing always check the mast with binoculars or camera to ensure there are no twisted shackles or, especially, T bar terminals (which is why I don't recommend T bars on trailable boats.) Use tape or elastic band to hold the stays in the correct position while hoisting - both will break away as the shrouds tighten.

0

2,234

Just the average day in the life of living on a brand new catamaran! Thanks for watching! Please subscribe and leave a comment ⛵️ To support our work ❤️ https://www.patreon.com/sailingrubyrose Our videos are free for everyone to watch, and always will be. However, we have an amazing community of Patrons who, for the cost of a cup of coffee a month, receive all sorts of benefits and perks. This support allows us to continue bringing our stories to you, so a HUGE thanks to our wonderful Patrons 😊 Click the link above to find out more. SOCIAL MEDIA http://www.instagram.com/sailingrubyrose http://www.facebook.com/sailingrubyrose https://www.tiktok.com/@sailingrubyrose MUSIC Epidemic Sound Artlist Hey there! We're Nick and Terysa and we’ve become completely obsessed with the idea of sailing around the world and sharing our experiences and information through our sailing lifestyle videos with others. We met travelling around India, and quickly agreed that rather than “settling down” and doing what most normal people do, we wanted to travel and adventure instead and started our sailing lifestyle adventure stories, since then, we’ve been working hard towards achieving our dreams, and now we’re finally living them as sailing cruising lifestyle! Want to know anything about our sailing lifestyle or sailing adventure stories? Send us an email via the contact us page http://yachtrubyrose.com/contact-us/ We hope you enjoy what we do. Please subscribe, like and share.

0

24,422

We need your help! Our skater boy has been added to our collection of Tees and Hoodies, but needs a name. Enter your suggestions in the comments below... We will choose our top 3 and run an Instagram poll so we can baptise this bad boyyyy. #skateboarding #skate #skater #blender3d #skateboard Check out the collection at: https://my-store-ed9038.creator-spring.com/listing/urban-speed-skater https://my-store-ed9038.creator-spring.com/listing/get-urban-bunny Created with Blender3D: www.blender.org